| 標題：柴油發電機及空壓機操作規范（中英文） |
| 柴油發電機及空壓機操作規范（中英文） 一，單機操作（手動啟動） 1，保持機房及設備衛生，保持機組的進排風通暢，不能堆放任何雜物及容易漂浮的物品在機房。 Please keep the machine house and generator clean, keep the machine group e*haust-system go well and do not pack any other rubbish things inside the house. 2, 開機前補充水箱冷卻液，電瓶液位，檢查機油，柴油。空壓機啟動不是控制器控制的，屬于操作人員手動啟動，在按下啟動按鈕后聽到啟動_，也可以按8秒時間計算，及時松開按鈕，如果沒有啟動成功也要及時松開啟動按鈕；啟動時間太長容易燒壞啟動馬達。間隔15秒后在啟動。3次未啟動成功及時通知維修人員到現場檢查。 Check the engine coolant of radiator, battery water, engion oil and the diesel. Starting the generator is not automatic, it must be started by operator, it will be successful if you hear the engine voice when you press the starting button or you also calculate when it reach 8 seconds, at this time loose the starting ……（快文網http://hoachina.com省略1180字，正式會員可完整閱讀）…… 6, 柴油發電機盡可能在額定負載70%的工況下工作，避免長期時間在85%以上負載運行。也不能長期處于20%以下負載工作。在不影響生產的情況下，每天盡量讓機組停機2小時。機組停機半小時后可檢查機油油位，啟動前檢查冷卻水位。 Dissele generator group should be working at the condition 70% of rated load, avoid working at above 85% of rated load for long time, also avoid working at below 20% of rated load for long time. Try to stop the engine about 2 hours for break every day, after stopping engine about half hour, the operator should check the engine oil position, check the collant positon before starting the engine. 7, 空載時間不能太長，2分鐘內就可以。停機前先卸負載1-3分鐘后在停機，柴油空壓機也是先卸載，打開泄壓閥后1-3分鐘后再停機。 The engine can not be at the condiotion more than 2 minutes without load. Stop the engine after 1-3 minutes of load-relief. Diesel-air-compressor should be the same operatng procedure, stop the compressor after 1-3 minutes of load-relief. 8, 控制器設有手動，自動，應急三種啟動方式。我們主要是用手動啟動，選擇手動按鈕鍵，按下手動模式鍵等燈亮起后，按綠色鍵啟動，紅色鍵停機。帶！是消除警報，也可以斷控制器的工作電來消除警報。 The progamma controller is setted with manual,automatic,emergency for starting mode. Manual starting mode is always used by us, choose the manual button, press the mode botton, when the light is on, press the strating button with the color is green, the button with red color means stop the engine, “！”means cancel alarm, also remove the alarm through off the controller. 9, 機房隨時保持有中國人在機房附近值班，注意聽機器有無異常_，發現異常_及漏油漏水情況及時停機并告知維修人員到現場處理。Chinese must be always on duty around the generator house, listen to the voice of generator carefully, once found the non-normal noise, oil leakage or water leakage, please inform the mechenic to check and repair in time. 二，雙機操作（并機啟動） 1，在兩臺機組滿足水箱的液位，機油油位及柴油在正常的情況下可以選擇并機使用。When the water position of the two generators satisfied the level of radiator, also engine oil and diesel supposed to be normal level, at this condition, the two genereators can be on parallel connection. 2，先打開控制柜電源鑰匙，等控制器顯示正常后，將兩臺柴油發電機組的啟動方式選擇在手動模式。Please open the power key of the controller, until the controller pannel display normal, set it manuel of starting mode of the dissel ……（未完，全文共6370字，當前只顯示3067字，請閱讀下面提示信息。收藏柴油發電機及空壓機操作規范（中英文）） 上一篇：村發展壯大村級集體經濟典型案例 下一篇：工作投入一線去 成績寫到大地上 相關欄目： |